A Study on the Metal Induced Lateral Crystallization Behavior of Amorphous Silicon Thin Films

1996 ◽  
Vol 441 ◽  
Author(s):  
Byung-Il Lee ◽  
Kwang-Ho Kim ◽  
Won-Cheol Jeong ◽  
Pyung-Su Ahn ◽  
Jin-Wook Shin ◽  
...  
Keyword(s):  
Thin Films ◽  
Amorphous Silicon ◽  
Crystallization Behavior ◽  
Crystallization Rate ◽  
External Stress ◽  
Tem Analysis ◽  
Silicon Thin Films ◽  
Amorphous Si ◽  
Lateral Crystallization ◽  
Si Films

AbstractBasic mechanisms for both Ni- and Pd-metal induced lateral crystallization (MILC) are investigated. For both cases, tiny silicides were formed under the metal deposited area, and propagated toward amorphous Si films leaving crystallized Si behind at temperatures as low as 500 °C. Ni-MILC was influenced by Pd such that the lateral crystallization rate was enhanced, and the temperature for the lateral crystallization was lowered to 450 °C. Through TEM analysis and external stress experiments, it was found that the enhancement of the lateral crystallization rate was closely related to the compressive stress generated by the formation of nearby Pd2Si.

Formation of Large, Orientation-Controlled, Nearly Single Crystalline Si Thin Films on SiO2 Using Contact Printing of Rolled and Annealed Nickel Tapes

2003 ◽  
Vol 762 ◽  
Author(s):  
Hwang Huh ◽  
Jung H. Shin
Keyword(s):  
Electron Microscopy ◽  
Thin Films ◽  
High Resolution ◽  
Amorphous Silicon ◽  
Tem Analysis ◽  
Contact Printing ◽  
Single Crystalline ◽  
High Resolution Tem ◽  
Lateral Crystallization ◽  
Si Films

AbstractAmorphous silicon (a-Si) films prepared on oxidized silicon wafer were crystallized to a highly textured form using contact printing of rolled and annealed nickel tapes. Crystallization was achieved by first annealing the a-Si film in contact with patterned Ni tape at 600°C for 20 min in a flowing forming gas (90 % N2, 10 % H2) environment, then removing the Ni tape and further annealing the a-Si film in vacuum for2hrsat600°C. An array of crystalline regions with diameters of up to 20 μm could be formed. Electron microscopy indicates that the regions are essentially single-crystalline except for the presence of twins and/or type A-B formations, and that all regions have the same orientation in all 3 directions even when separated by more than hundreds of microns. High resolution TEM analysis shows that formation of such orientation-controlled, nearly single crystalline regions is due to formation of nearly single crystalline NiSi2 under the point of contact, which then acts as the template for silicide-induced lateral crystallization. Furthermore, the orientation relationship between Si grains and Ni tape is observed to be Si (110) || Ni (001)

Crystallization of Amorphous Silicon Thin Films by Microwave Heating

2014 ◽  
Vol 1666 ◽  
Author(s):  
Tomohiko Nakamura ◽  
Shinya Yoshidomi ◽  
Masahiko Hasumi ◽  
Toshiyuki Sameshima ◽  
Tomohisa Mizuno
Keyword(s):  
Thin Films ◽  
Heat Treatment ◽  
Amorphous Silicon ◽  
Microwave Heating ◽  
Volume Ratio ◽  
Heated Sample ◽  
Silicon Thin Films ◽  
Scattering Spectra ◽  
Raman Scattering Spectra ◽  
Si Films

ABSTRACTWe report crystallization of amorphous silicon (a-Si) thin films and improvement of thin film transistors (TFTs) characteristics using 2.45 GHz microwave heating assisted with carbon powders. Undoped 50-nm-thick a-Si films were formed on quartz substrates and heated by microwave irradiation for 2, 3, and 4 min. Raman scattering spectra revealed that the crystalline volume ratio increased to 0.42 for the 4-min heated sample. The dark and photo electrical conductivities measured by Air mass 1.5 at 100 mW/cm2 were 2.6x10-6 and 5.2x10-6 S/cm in the case of 4-min microwave heating followed by 1.3x106-Pa-H2O vapor heat treatment at 260°C for 3 h. N channel polycrystalline silicon TFTs characteristics were improved by the combination of microwave heating with high-pressure H2O vapor heat treatment. The threshold voltage decreased from 5.3 to 4.2 V and the effective carrier mobility increased from 18 to 25 cm2/Vs.

Poly-Si films with long carrier lifetime prepared by rapid thermal annealing of Cat-CVD amorphous silicon thin films

2008 ◽  
Vol 516 (5) ◽  
pp. 600-603 ◽  
Author(s):  
Keisuke Ohdaira ◽  
Yuki Abe ◽  
Makoto Fukuda ◽  
Shogo Nishizaki ◽  
Noritaka Usami ◽  
...  
Keyword(s):  
Thin Films ◽  
Amorphous Silicon ◽  
Thermal Annealing ◽  
Rapid Thermal Annealing ◽  
Carrier Lifetime ◽  
Silicon Thin Films ◽  
Si Films

Hydrogen Configurations in Microcrystallized Sputtered Amorphous Silicon.

1992 ◽  
Vol 283 ◽  
Author(s):  
L. Lusson ◽  
P. Elkaim ◽  
M. Cuniot ◽  
D. Ballutaud ◽  
R. Rizk ◽  
...  
Keyword(s):  
Thin Films ◽  
Amorphous Silicon ◽  
Molecular Hydrogen ◽  
Film Growth ◽  
Amorphous Film ◽  
Microcrystalline Silicon ◽  
Silicon Thin Films ◽  
Si Films ◽  
Small Clusters ◽  
Secondary Ion

ABSTRACTSuccessive deuterium diffusion and effusion experiments are performed on undoped microcrystalline silicon obtained from thermally crystallized sputtered amorphous silicon thin films. The effect of prior incorporation of deuterium during the amorphous film growth on the crystallization mechanism and on the microcrystalline film quality is probed by the use of the post hydrogenation procedure. In connection with the deuterium solubility as provided by secondary ion mass spectroscopy (SIMS) profiling, the analysis of the effusion spectra suggests the existence of large cavities in the crystallized a-Si:D films, containing most probably molecular hydrogen. They are absent in the corresponding crystallized non-deuterated a-Si films. Other deuterium configurations seem to be present in both kinds of samples such as weakly bonded deuterium in small clusters and at grain boundaries.

In situ observation of nickel metal-induced lateral crystallization of amorphous silicon thin films

2002 ◽  
Vol 80 (6) ◽  
pp. 944-946 ◽  
Author(s):  
Mitsutoshi Miyasaka ◽  
Kenji Makihira ◽  
Tanemasa Asano ◽  
Efstathios Polychroniadis ◽  
John Stoemenos
Keyword(s):  
Thin Films ◽  
Amorphous Silicon ◽  
In Situ Observation ◽  
Nickel Metal ◽  
Silicon Thin Films ◽  
Lateral Crystallization
Sign in / Sign up

Export Citation Format

Share Document