Meta-proteomics analysis of microbial ecosystem during the anaerobic digestion of chicken manure in biogas production farm

2021 ◽  
Vol 13 ◽  
pp. 100643
Author(s):  
Tze-Kang Lam ◽  
Jhih-Tian Yang ◽  
Shu-Jung Lai ◽  
Suh-Yuen Liang ◽  
Shih-Hsiung Wu
Keyword(s):  
Anaerobic Digestion ◽  
Biogas Production ◽  
Chicken Manure ◽  
Proteomics Analysis ◽  
Microbial Ecosystem

scholarly journals Performance of Anaerobic Digestion of Chicken Manure Under Gradually Elevated Organic Loading Rates

2019 ◽  
Vol 16 (12) ◽  
pp. 2239 ◽  
Author(s):  
Fei Wang ◽  
Mengfu Pei ◽  
Ling Qiu ◽  
Yiqing Yao ◽  
Congguang Zhang ◽  
...  
Keyword(s):  
Anaerobic Digestion ◽  
Biogas Production ◽  
Poultry Manure ◽  
Ammonia Nitrogen ◽  
Methane Content ◽  
Chicken Manure ◽  
Continuous Stirred Tank Reactor ◽  
Organic Loading ◽  
Biogas Yield ◽  
Loading Rates

Poultry manure is the main source of agricultural and rural non-point source pollution, and its effective disposal through anaerobic digestion (AD) is of great significance; meanwhile, the high nitrogen content of chicken manure makes it a typical feedstock for anaerobic digestion. The performance of chicken-manure-based AD at gradient organic loading rates (OLRs) in a continuous stirred tank reactor (CSTR) was investigated herein. The whole AD process was divided into five stages according to different OLRs, and it lasted for 150 days. The results showed that the biogas yield increased with increasing OLR, which was based on the volatile solids (VS), before reaching up to 11.5 g VS/(L·d), while the methane content was kept relatively stable and maintained at approximately 60%. However, when the VS was further increased to 11.5 g VS/(L·d), the total ammonia nitrogen (TAN), pH, and alkalinity (CaCO3) rose to 2560 mg·L−1, 8.2, and 15,000 mg·L−1, respectively, while the volumetric biogas production rate (VBPR), methane content, and VS removal efficiency decreased to 0.30 L·(L·d)−1, 45%, and 40%, respectively. Therefore, the AD performance immediately deteriorated and ammonia inhibition occurred. Further analysis demonstrated that the microbial biomass yield and concentrations dropped dramatically in this period. These results indicated that the AD stayed steady when the OLR was lower than 11.5 g VS/(L·d); this also provides valuable information for improving the efficiency and stability of AD of a nitrogen-rich substrate.

Study of Methane Production by High Temperature Anaerobic Fermentation of Chicken Manure and Stalks

2020 ◽  
Vol 14 (4) ◽  
pp. 551-557
Author(s):  
Yongku Li ◽  
Xiaomin Hu ◽  
Lei Feng
Keyword(s):  
High Temperature ◽  
Anaerobic Digestion ◽  
Production Rate ◽  
Methane Production ◽  
Anaerobic Fermentation ◽  
Biogas Production ◽  
Gas Production ◽  
Chicken Manure ◽  
Biogas Slurry ◽  
Production Rates

The changing parameters, as the biogas production rate, the methane production rate, the cumulative biogas amount, the cumulative methane amount, the biogas composition, pH etc. in high temperature anaerobic fermentation of chicken manure and stalks were analyzed by experiments with different mass ratios of chicken manure or livestock manure and stalks with a high C/N ratio. The methane production mechanism of high temperature anaerobic digestion of chicken manure and stalks was discussed in detail. It showed that not only the biogas production rates but also the methane production rates of R1–R7 demonstrated the trend of initial increase and then decrease after 50 d of high temperature anaerobic digestion. Besides, the gas production of R1 with pure chicken manure stopped on the 30th d of the reaction. The gas production of other groups R2–R7 also stopped on the corresponding 34th, 36th, 36th, 37th, 37th, and 37th day, respectively. At the end of the reaction, the cumulative biogas amounts and the cumulative methane amounts of R1–R7 were 411.58 and 269.54, 459.91 and 314.41, 425.32 and 294.11, 401.85 and 272.54, 382.63 and 257.07, 363.04 and 218.16, and 257.15 and 160.10 N ml/(g VS). The biogas slurry pH of R1–R7 all demonstrated a trend of initial decrease and then increase, e. g., pH of R2 reached the minimum of 5.94 on the 5th day. pH values of other groups were between 6.01 and 6.39. After the addition of 4 g of sodium bicarbonate on the 7th day, biogas slurry pH of R1–R7 all increased. pH was maintained between 7.16 and 7.44 until the end of the reaction.

scholarly journals Integration of Catalytic Biofuel Production and Anaerobic Digestion for Biogas Production

2021 ◽  
pp. 125-131
Author(s):  
G. Hurst ◽  
M. Peeters ◽  
S. Tedesco
Keyword(s):  
Anaerobic Digestion ◽  
Biogas Production ◽  
Biofuel Production ◽  
Chicken Manure ◽  
Solid Residue ◽  
Low Carbon ◽  
Waste Products ◽  
Low Carbon Economy ◽  
Promising Solution ◽  
Management Method

AbstractThe drive towards a low carbon economy will lead to an increase in new lignocellulosic biorefinery activities. Integration of biorefinery waste products into established bioenergy technologies could lead to synergies for increased bioenergy production. In this study, we show that solid residue from the acid hydrolysis production of levulinic acid, has hydrochar properties and can be utilised as an Anaerobic Digestion (AD) supplement. The addition of 6 g/L solid residue to the AD of ammonia inhibited chicken manure improved methane yields by +14.1%. The co-digestion of biorefinery waste solids and manures could be a promising solution for improving biogas production from animal manures, sustainable waste management method and possible form of carbon sequestration.

Biogas production from chicken manure at different organic loading rates in a mesophilic full scale anaerobic digestion plant

2020 ◽  
Vol 141 ◽  
pp. 105693 ◽  
Author(s):  
Linas Jurgutis ◽  
Alvyra Slepetiene ◽  
Jonas Volungevicius ◽  
Kristina Amaleviciute-Volunge
Keyword(s):  
Anaerobic Digestion ◽  
Biogas Production ◽  
Full Scale ◽  
Chicken Manure ◽  
Organic Loading ◽  
Loading Rates

scholarly journals Digested residue as a fertilizer after the mesophilic process of anaerobic digestion

2011 ◽  
Vol 51 (No. 6) ◽  
pp. 262-266 ◽  
Author(s):  
N. Voća ◽  
T. Krička ◽  
T. Ćosić ◽  
V. Rupić ◽  
Ž. Jukić ◽  
...  
Keyword(s):  
Anaerobic Digestion ◽  
Pathogenic Bacteria ◽  
Biogas Production ◽  
Raw Materials ◽  
Chicken Manure ◽  
Plant Production ◽  
Household Waste ◽  
Biogenic Elements ◽  
Pig Manure ◽  
Thermophilic Microorganisms

The aim of this paper is to determine the difference in quality of the digested residue after the process of anaerobic digestion by using different input raw materials. The research was conducted in the Republic of Austria on four facilities for biogas production. The raw materials used for biogas production were chicken manure, pig manure, Sudan grass and organic household waste. The research included chemical analysis and bacteriological tests of the samples taken. It was found that the digested residue in all of the samples, all of which are mildly alkaline, contains a low level of dry matter, 70% of which is organic matter. Biogenic elements were present in moderate concentration; the values of heavy metals were within approved limits. This analysis leads to the conclusion that the digested residues of all input materials can be used in agricultural production, especially so in plant production and grassland cultivation. Mesophilic and thermophilic microorganisms were found in the digested residue samples, but there were no cryophilic microorganisms and no pathogenic bacteria.

Improved Biogas Production from Chicken Manure Anaerobic Digestion Using Cereal Residues as Co-substrates

2014 ◽  
Vol 28 (4) ◽  
pp. 2490-2495 ◽  
Author(s):  
Tong Zhang ◽  
Yuheng Yang ◽  
Linlin Liu ◽  
Youyang Han ◽  
Guangxin Ren ◽  
...  
Keyword(s):  
Anaerobic Digestion ◽  
Biogas Production ◽  
Chicken Manure ◽  
Cereal Residues
Sign in / Sign up

Export Citation Format

Share Document